Crambe fruit drying with natural air in stationary dryers

Sebastião Rodrigues Cardoso Neto, Osvaldo Resende Resende, Lilian Moreira Costa, Daniel Emanuel Cabral de Oliveira

Resumo


The aim of this study was to assess the drying behavior and quality of crambe fruit seeds dried with natural air and submitted to different airflows in stationary dryers. Dryings were carried out in July and September 2014. The experiment consisted of three treatments of drying the crambe fruits with natural air in stationary dryers with airflows of 10.08, 15.05, and 25.03 m3 min−1 t−1 and a control treatment composed of crambe fruits with an initial moisture content without going through the drying process. After drying, tests of moisture content, germination, germination rate index, and electrical conductivity were performed in order to compare the treatments. The data were submitted to analysis of variance and mean comparison by the Tukey’s test at 5% significance. Among the airflows used in the experiment in both natural air dryings in July and September, no interference was observed for crambe fruit quality. Drying carried out in September was faster and showed a lower expenditure and cost of electricity when compared to that performed in July, which is due to better climatic conditions. No difference was observed in the drying times between airflows, but the drying with natural air using an airflow of 15.05 m3 min−1 t−1 was more profitable.

Palavras-chave


Moisture content; Physiological quality; Biodiesel

Texto completo:

PDF

Referências


ARAUJO, W. D. et al. Propriedades físicas dos grãos de amendoim durante a secagem. Revista Brasileira de Engenharia Agrícola e Ambiental, v. 18, n. 3, p. 279-286, 2014.

BITTENCOURT, E. Biodiesel: matéria prima - crambe tem alto potencial: oleaginosa pode ser produzida em larga escala e a baixo custo no período da safrinha. Canal – Jornal da Bioenergia, v. 4, n. 46, 2010.

BRASIL. Ministério da Agricultura e Reforma Agrária. Secretaria Nacional de Defesa Agropecuária. Regras para análise de sementes. Brasília, 2009. 395 p.

CELG DISTRIBUIÇÃO. Boletim de Tarifa Convencional nº 01/2015. 2015. Disponível em: . Acesso em: 10 set. 2015.

COLODETTI, T. V. et al. Crambe: aspectos gerais da produção agrícola. Enciclopédia Biosfera, v. 8, n. 14, p. 258-269, 2012.

CORRÊA, P. C. et al. Modelagem matemática e determinação das propriedades termodinâmicas do café (Coffea arábica L.) durante o processo de secagem. Revista Ceres, v. 57, n. 5, p. 595-601, 2010.

ELIAS, M. C. Manejo tecnológico da secagem e do armazenamento de grãos. Pelotas: Santa Cruz, 2008. 457 p.

FARIA, R. Q. et al. Qualidade fisiológica da semente de crambe submetido a secagem. Revista Ciência Agronômica, v. 45, n. 3, p. 453-460, 2014.

FERREIRA, F. M.; SILVA, A. R. B. Produtividade de grãos e teor de óleo da cultura do crambe sob diferentes sistemas de manejo de solo em Rondonópolis – MT. Revista Enciclopédia Biosfera, v. 7, n. 12, p. 1-11, 2011.

JASPER, S. P. et al. Análise energética da cultura do crambe (Crambe Abyssinica Hochst) produzida em plantio direto. Engenharia Agrícola, v. 30, n. 3, p. 395-403, 2010.

MAGUIRE, J. D. Speed of germination aid in selection and evaluation for seedling emergence and vigor. Crop Science, v. 2, n. 1, p. 176-177, 1962.

OLIVA, A. C. E.; BIAGGIONI, M. A. M.; CAVARIANI, C. Efeito imediato do método de secagem na qualidade de sementes de crambe. Revista Energia na Agricultura, v. 27, n. 3, p. 16-30, 2012.

OLIVEIRA, F. N. et al. Qualidade fisiológica de sementes de girassol avaliadas por condutividade elétrica. Pesquisa Agropecuária Brasileira, v. 42, n. 3, p. 279-287, 2012.

PEREIRA, C. M. P. et al. Biodiesel renovável derivado de microalgas: avanços e perspectivas tecnológicas. Química Nova, v. 35, n. 10, p. 2013-2018, 2012.

PIMENTEL, G. F.; GARCIA, C. H. Estatística aplicada a experimentos agronômicos e florestais, exposição com exemplos e orientações para uso de aplicativos. Piracicaba: FEALQ, 2002. 309 p.

PIMENTEL, M. A. G.; FONSECA, M. J. O. Cultivo do milho: sistema de produção. 7. ed. Embrapa versão eletrônica, 2011. Disponível em: . Acesso em: 2 out. 2015.

RESENDE, O. et al. Modelagem matemática e difusividade efetiva das sementes de pinhão-manso (Jatropha curcas L.) durante a secagem. Revista Engenharia Agrícola, v. 31, n. 6, p. 1123-1135, 2011.

SCHUH, G. et al. Efeitos de dois métodos de secagem sobre a qualidade físico-química de grãos de milho safrinha - RS, armazenados por 6 meses. Semina: Ciências Agrárias, v. 32, n. 1, p. 235-244, 2011.

SILVA, J. S. Secagem e armazenamento de produtos agrícolas. 2. ed. Viçosa: Aprenda Fácil, 2008. 560 p.

SILVA, L. C. da. Secagem de grãos. Alegre: UFES. Departamento de Engenharia Rural, 2005. 9 p. (Boletim Técnico: AG: 04/05). Disponível em: . Acesso em: 29 out. 2015.

SILVA, M. A. P. et al. Influência do pericarpo no teste de condutividade elétrica em sementes de crambe (Crambe abyssinica hochst) submetidas a métodos de secagem. Energia na Agricultura, v. 29, n. 4, p. 301-305, 2014.

SOUZA, A. D. V. et al. Caracterização química de sementes e tortas de pinhão-manso, nabo-forrageiro e crambe. Pesquisa Agropecuária Brasileira, v. 44, n. 10, p. 1328-1335, 2009.




Revista Ciência Agronômica ISSN 1806-6690 (online) 0045-6888 (impresso), Site: www.ccarevista.ufc.br, e-mail: ccarev@ufc.br - Fone: (85) 3366.9702 - Expediente: 2ª a 6ª feira - de 7 às 17h.